皮革及其制品中短链氯化石蜡的风险分析

doi:10.19677/j.issn.1004-7964.2022.04.006

皮革科学与工程 ›› 2022, Vol. 32 ›› Issue (4): 32-39.doi: 10.19677/j.issn.1004-7964.2022.04.006

皮革及其制品中短链氯化石蜡的风险分析

吴晓波^1,*, 任可帅^2,*, 王春华¹, 桑军^2**, 林炜¹

1.四川大学制革清洁技术国家工程实验室,四川大学轻工科学与工程学院,四川成都 610065;
2.中国皮革制鞋研究院有限公司,北京 100015

收稿日期:2021-09-30 出版日期:2022-08-28 上线日期:2022-07-11
通讯作者: **桑军,男,工程师,E-mail: sang8888@163.com,主要研究方向为皮革、毛皮产品质量检验及标准化。
作者简介:*吴晓波（1997-）,男,硕士研究生,E-mail: 705156952@qq.com;任可帅（1990-）,男,工程师,E-mail:renkeshuai@126.com。
基金资助:
国家重点研发计划重点专项(2019YFC1904500)

Risk Analysis of Short Chain Chlorinated Paraffins in Leather and Related Products

WU Xiaobo^1,*, REN Keshuai^2,*, WANG Chunhua¹, SANG Jun^2,**, LIN Wei¹

1. National Engineering Laboratory for Clean Technology of Leather Manufacture, College of Biomass Science and Engineering, Sichuan University, Chengdu 610065, China;
2. China Leather & Footwear Research Institute Co. Ltd., Beijing 100015, China

Received:2021-09-30 Online:2022-08-28 Published:2022-07-11

摘要/Abstract

摘要： 短链氯化石蜡(SCCPs)因其优良的使用性能和相对低廉的价格而广泛应用于皮革及其制品行业,但其具备典型持久性有机污染物(POPs)的特性,已成为近年来备受关注的环境污染物。分析了SCCPs在皮革及其制品中的来源、毒性效应,总结了国内外对SCCPs的限制情况,并进一步指出了我国皮革行业及有关部门应该采取的应对策略。

关键词: 短链氯化石蜡, 皮革及其制品, 毒性, 限制, 展望

Abstract: Short chain chlorinated paraffins (SCCPs) have been widely used in leather and related products because of its good properties and low cost. However, in recently yeas, SCCPs have caused much concern as they possess the characteristics of typical persistent organic pollutants (POPs). In this paper, the sources and toxicity of SCCPs in leather and related products were analyzed, and the restrictions on SCCPs at home and abroad were summarized. In addition, the coping strategies for China leather industry and related administration department are proposed.

Key words: short chain chlorinated paraffins, leather and related products, toxicity, limitation, prospect

中图分类号:

TS57

吴晓波, 任可帅, 王春华, 桑军, 林炜. 皮革及其制品中短链氯化石蜡的风险分析[J]. 皮革科学与工程, 2022, 32(4): 32-39.

WU Xiaobo, REN Keshuai, WANG Chunhua, SANG Jun, LIN Wei. Risk Analysis of Short Chain Chlorinated Paraffins in Leather and Related Products[J]. Leather Science and Engineering, 2022, 32(4): 32-39.

参考文献

[1] United Nations Environment Programme[S].Revised Draft Risk Profile:Short-Chained Chlorinated Paraffins(UNEP/POPS/POPRC.5/2/Rev.1).2009.
[2] United States Environmental Protection Agency[S].Short-Chain Chlorinated Paraffins(SCCPs)and Other Chlorinated Paraffins Action Plan.2009.
[3] Wang X,Zhu J,Kong B,et al.C9-13 Chlorinated Paraffins Cause Immunomodulatory Effects in Adult C57BL/6 Mice[J].Science of the Total Environment,2019,675:110-121.
[4] Geng N,Ren X,Gong Y,et al.Integration of Metabolomics and Transcriptomics Reveals Short-Chain Chlorinated Paraffin-Induced Hepatotoxicity in Male Sprague-Dawley Rat[J].Environment International,2019,133:105231.
[5] Government of Canada,Environment Canada,Health and Welfare Canada[S].Priority Substances List Assessment Report:Chlorinated Paraffins.1993.
[6] United States National Toxicology Program.NTP Toxicology and Carcinogenesis Studies of Chlorinated Paraffins(C12,60%Chlorine)(CAS No.108171-26-2*)in F344/N Rats and B6C3F1 Mice(Gavage Studies)[R].National Toxicology Program Technical Report Series.1986,308:1-206.
[7] International Research and Development Corporation.Teratology Study in Rabbits with Chlorinated Paraffin:58%Chlorination of Short Chain Length n-Paraffin.Studies Conducted For The Working Party Of The Chlorinated Paraffin Manufacturers Toxicology Testing Consortium(Report No 438-031)[R].Mattawan,Michigan,USA,1983.
[8] Liu L,Li Y,Coelhan M,et al.Relative Developmental Toxicity of Short-Chain Chlorinated Paraffins in Zebrafish(Danio Rerio) Embryos[J]. Environmental Pollution, 2016, 219: 1122-1130.
[9] 谢素香.新华视点|当心！塑料书包里的隐形“杀手”[EB/OL].2021-4.http://m.xinhuanet.com/gz/2021-04/22/c_1127362218.htm
[10] 周华龙,何有节.皮革化工材料学[M].北京:科学出版社,2010.
[11] 肖湾,顾春思,郝晓红,等.GC-NCI-MS测定皮革中短链氯化石蜡[J].西部皮革,2020,(13):13-14.
[12] 马贺伟. 皮革中短链氯化石蜡的GC-ECD测定方法探讨[J].中国皮革,2012,41(1):1-3.
[13] 沈浩,林丽娜,程洁,等.气相色谱-负化学离子源质谱法测定皮革中短链氯化石蜡[J].化学计量分析,2021,30(4):42-44+49.
[14] 章杰. 2016年禁限用纺织化学品最新动态(续一)[J].印染助剂,2016,33(7):1-12.
[15] 章杰. 高度关注化学物质(SVHC)的替代研究进展(一)[J].印染,2011,37(3):47-50.
[16] 章杰,晓琴.ETAD最近修正的染料中有机杂质及其限制值解读(续)[J].染整技术,2015,37(6):44-49.
[17] 郑结斌. 中国氯化石蜡行业现状及发展分析[J].中国氯碱,2021(1):22-24.
[18] GB/T 4754-2017,国民经济行业分类[S].2017.
[19] Alexander P,Milos M,Jakob W,et al.Identification of Potentially POP-Containing Wastes and Recyclates—Derivation of Limit Values[R].German Federal Environment Agency,2015.
[20] United Nations Environment Programme[S].Draft Technical Guidelines on The Environmentally Sound Management of Wastes Consisting of,Containing or Contaminated with Short-Chain Chlorinated Paraffins(UNEP/CHW/OEWG.11/INF/10).2018.
[21] Hahladakis J N,Velis C A,Weber R,et al.An Overview of Chemical Additives Present in Plastics:Migration,Release,Fate and Environmental Impact During Their Use,Disposal and Recycling[J].Journal Of Hazardous Materials,2018,344:179-199.
[22] International Agency for Research on Cancer.Summaries and evaluations:Chlorinated paraffins(Group 2B)[EB/OL].1998-10.https://inchem.org/documents/iarc/vol48/48-02.html.
[23] Bardin J A,Gore R J,Wegman D H,et al.Registry-Based Case-Control Studies of Liver Cancer and Cancers of The Biliary Tract Nested in a Cohort of Autoworkers Exposed to Metalworking Fluids[J].Scandinavian Journal of Work Environment&Health,2005,31(3):205-211.
[24] International Research and Development Corporation.Teratology Study in Rabbits with Chlorinated Paraffin:70%Chlorination of Long Chain Length n-Paraffin.Studies Conducted for The Working Party of the Chlorinated Paraffin Manufacturers Toxicology Testing Consortium(Report No 438-039)[R].Mattawan,Michigan,USA,1982.
[25] Liu Y,Aamir M,Li M,et al.Prenatal and Postnatal Exposure Risk Assessment of Chlorinated Paraffins in Mothers and Neonates:Occurrence,Congener Profile,and Transfer Behavior[J].Journal of Hazardous Materials,2020,395.
[26] Qiao L,Gao L,Zheng M,et al.Mass Fractions,Congener Group Patterns,and Placental Transfer of Short-and Medium-Chain Chlorinated Paraffins in Paired Maternal and Cord Serum[J].Environmental Science & Technology, 2018, 52(17):10097-10103.
[27] Huang H,Gao L,Xia D,et al.Characterization of Short-and Medium-Chain Chlorinated Paraffins in Outdoor/Indoor PM10/PM2.5/PM1.0 in Beijing,China[J].Environmental Pollution,2017,225:674-680.
[28] 李玉红,廖学品,王安.基于LCA方法对毛皮加工过程的环境影响评价[J].皮革科学与工程,2020,30(2):06-11.
[29] Aamir M,Yin S,Zhou Y,et al.Congener-Specific C-10-C-13 and C-14-C-17 Chlorinated Paraffins in Chinese Agricultural Soils:Spatio-Vertical Distribution,Homologue Pattern and Environmental Behavior[J].Environmental Pollution,2019,245:789-798.
[30] United Nations Environment Programme[S].Revised draft risk profile: short- chained chlorinated paraffins( UN EP/POPS/POPRC.5/2),2009.
[31] Koh I-O,Thiemann W.Study of Photochemical Oxidation of Standard Chlorinated Paraffins and Identification of Degradation Products[J].Journal of Photochemistry and Photobiology A:Chemistry,2001,139:205-215.
[32] Thompson R S,Noble H.Short-Chain Chlorinated Paraffins(C10-13,65%Chlorinated):Aerobic and Anaerobic Transformation in Marine and Freshwater Sediment Systems.Draft Report No BL8405/B[R].AstraZeneca UK Limited,2007.
[33] Fisk A T,Wiens S C,Webster G R B,et al.Accumulation and Depuration of Sediment-Sorbed C12-and C16-Polychlorinated Alkanes by Oligochaetes(Lumbriculus Variegatus)[J].Environmental Toxicology and Chemistry,1998,17(10):2019-2026.
[34] Dong Z,Li T,Wan Y,et al.Physiologically Based Pharmacokinetic Modeling for Chlorinated Paraffins in Rats and Humans:Importance of Biliary Excretion[J].Environmental Science&Technology,2020,54(2):938-946.
[35] Wu J,Gao W,Liang Y,et al.Spatiotemporal Distribution and Alpine Behavior of Short Chain Chlorinated Paraffins in Air at Shergyla Mountain and Lhasa on the Tibetan Plateau of China[J].Environmental Science&Technology,2017,51(19):11136-11144.
[36] Vorkamp K,Balmer J,Hung H,et al.A Review of Chlorinated Paraffin Contamination in Arctic Ecosystems[J].Emerging Contaminants,2019,5:219-231.
[37] Ma X,Zhang H,Zhou H,et al.Occurrence and Gas/Particle Partitioning of Short-and Medium-Chain Chlorinated Paraffins in the Atmosphere of Fildes Peninsula of Antarctica[J].Atmospheric Environment,2014,90:10-15.
[38] Stern G,Evans M.Persistent Organic Pollutants in Marine and Lake Sediments.In:Bidleman T,Macdonald R,and Stow J(eds)Canadian Arctic Contaminants Assessment Report II.Sources,Occurrence,Trends and Pathways in the Physical Environment[M].Minister of Public Works and Government Services Canada..2003:pp.100-115.
[39] Tomy G T,Muir D C G,Stern G A,et al.Levels of C-10-C-13 Polychloro-N-Alkanes in Marine Mammals from the Arctic and The St.Lawrence River Estuary[J].Environmental Science&Technology,2000,34(9):1615-1619.
[40] Reth M,Ciric A,Christensen G N,et al.Short-and Medium-Chain Chlorinated Paraffins in Biota from the European Arctic—Differences in Homologue Group Patterns[J].Science of The Total Environment,2006,367(1):252-260.
[41] Casa M V,Van Mourik L M,Weijs L,et al.First Detection of Short-Chain Chlorinated Paraffins(SCCPs)in Humpback Whales(Megaptera Novaeangliae)Foraging in Antarctic Waters[J].Environmental Pollution,2019,250:953-959.
[42] United States Environmental Protection Agency[S].Toxics Release Inventory:List of Toxic Chemicals within the Polychlorinated Alkanes Category and Guidance for Reporting.1995.
[43] 赵斌,王海燕,徐永明,等.短链氯化石蜡研究现状[J].环境与发展,2020,32(1):124-125.
[44] United States Environmental Protection Agency[S].Risk Management for Short-Chain Chlorinated Paraffins.2014.
[45] 佚名. 美国发布第17版限用物质清单[J].纺织检测与标准,2016(3):46.
[46] OSPAR Commission[S].PARCOM Decision 95/1 on the Phasing Out of Short Chained Chlorinated Paraffins.1995.
[47] European Commission.Directive 2000/60/EC of the European Parliament and of the Council of 23 October 2000 Establishing a Framework for Community Action in the Field of Water Policy[J].Official Journal of the European Communities.2000
[48] European Commission.Directive 2002/45/EC[J].Official Journal of the European Communities.2002.
[49] European Chemicals Agency[S].Inclusion of Substances of Very High Concern in The Candidate List(ED/67/2008).2008.
[50] European Commission.(EC)No 519/2012[J].Official Journal of the European Union.2012.
[51] European Commission.(EU)2015/2030[J].Official Journal of the European Union.2015.
[52] 李艳. 纺织染整助剂中短链氯化石蜡的检测技术研究[D].杭州:浙江理工大学,2014.
[53] Japan Ministry of Economy,Japan Trade and Industry Ministry of Health,Japan Labour and Welfare Ministry of the Environment.WTO Notification G/TBT/N/JPN/572.In:Technical Barriers to Trade Information Management System(ver 2.0.1.19930)[EB/OL].2017.http://tbtims.wto.org/en/RegularNotifications/View/138978
[54] Zero Discharge of Hazradous Chemicals Programme[S].Manufacturing Restricted Substances List Version 1.1 Zero Discharge of Hazardous Chemicals Programme.2015.
[55] 国际环保纺织协会.OEKO-TEX Standard 100[S].2013.
[56] 国际环保纺织协会.STANDARD 100 by OEKO-TEX Test Criteria:New Regulations in 2019[S].2019.
[57] 佚名. Leather Standard by OEKO-TEX@检测标准2019新规定[J].纺织检测与标准,2019,5(1):54.
[58] United Nations Environment Programme.The New POPs Under the Stockholm Convention[EB/OL].2017.http://chm.pops.int/Portals/0/download.aspx?d=UNEP-POPS-COP.8-SC-8-11.English.pdf
[59] 中国人民共和国工业和信息化部,科技部,财政部.关于印发《工业清洁生产推行“十二五”规划》的通知[EB/OL].2012-03.https://www.miit.gov.cn/jgsj/jns/gzdt/art/2020/art_46b57323371540c8964c7f421611b611.html
[60] 环境保护部,工业和信息化部,国家卫生和计划生育委员会.关于发布《优先控制化学品名录(第一批)》的公告[EB/OL].2017-12.http://www.mee.gov.cn/gkml/hbb/bgg/201712/t20171229_428832.htm
[61] GB/T 31009-2020.足部防护鞋(靴)限量物质要求及测试方法B/T 31009-2020.足部防护鞋(靴)限量物质要求及测试方法[S].2020.
[62] GB 36246-2018.中小学合成材料面层运动场地B 36246-2018.中小学合成材料面层运动场地[S].2018.
[63] European Commission.(EU)2019/1021[J].Official Journal of the European Union.2019.
[64] United Nations Environment Programme.Risk Management Evaluation on Short-Chain Chlorinated Paraffins(UNEP/POPS/POPRC.12/11/Add.3).Addendum in:Report of the Persistent Organic Pollutants Review Committee on the work of its twelfth meeting[R].Rome:Persistent Organic Pollutants Review Committee,2016.
[65] 蔡凯武,刘春.环保型塑料助剂的开发与应用进展[J].精细石油化工进展,2020,21(5):54-57.

皮革及其制品中短链氯化石蜡的风险分析

Risk Analysis of Short Chain Chlorinated Paraffins in Leather and Related Products

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	赵建明, 范浩军, 张磊, 袁翔, 王维新. 人造革合成革中的中链和短链氯化石蜡的测定——气相色谱-负化学离子源质谱法[J]. 皮革科学与工程, 2022, 32(6): 62-68.
[2]	彭良琼, 隆汶君, 何发明, 王睿, 张文华, 石碧. 发光细菌法评价坯革的生态毒性[J]. 皮革科学与工程, 2021, 31(6): 1-7.
[3]	何发明, 彭良琼, 林诗雨, 侯梦春, 张文华. 发光细菌法评价常用有机鞣剂的生态毒性[J]. 皮革科学与工程, 2021, 31(3): 14-18.
[4]	丁海燕, 张贝贝, 李运, 王全杰. 新型吸附材料与制革废水处理[J]. 皮革科学与工程, 2020, 30(4): 17-23.
[5]	孙丽莹, 高文伟, 李珊, 王俊超, 张泽天, 李正军. 角蛋白提取方法进展及提取技术应用选择建议[J]. 皮革科学与工程, 2020, 30(3): 20-27.
[6]	韩威妺;周萱;谭娟;彭良琼;张文华;. 发光细菌法评价典型制革表面活性剂的生态毒性[J]. , 2019, 29(02): 47-.
[7]	周伟杰;韩威妺;彭良琼;张文华;石碧;. pH对发光菌法测试Cr(Ⅲ)和Cr(Ⅵ)毒性的影响[J]. , 2017, 27(06): 5-9.
[8]	蔡白雪;罗媛媛;胡文炬;王豪;. 高跟鞋安全性能召回情况及相关法律法规分析[J]. , 2015, 25(03): 59-.
[9]	罗媛媛;蔡白雪;李成琴;胡文炬;. 童鞋召回中质量与限量标准情况分析[J]. , 2014, 24(04): 55-.
[10]	罗媛媛;蔡白雪;李成琴;胡文炬;. 童鞋召回中质量与限量标准情况分析[J]. , 2014, 24(04): 55-.
[11]	何健锋;温演庆;罗杨;黄旭;杨洁;何有节;. 苯胺苯酚类LC_(50)的3D-QSAR模型建立与分析[J]. , 2014, 24(01): 44-.
[12]	何健锋;温演庆;罗杨;黄旭;杨洁;何有节;. 苯胺苯酚类LC_(50)的3D-QSAR模型建立与分析[J]. , 2014, 24(01): 44-.
[13]	吕斌;马建中;高党鸽;高建静;霍永强;. 花椒籽油的研究进展及其在皮革中的应用展望[J]. , 2013, 23(03): 31-35.
[14]	吕斌;马建中;高党鸽;高建静;霍永强;. 花椒籽油的研究进展及其在皮革中的应用展望[J]. , 2013, 23(03): 31-35.
[15]	马贺伟;. 皮革中短链氯化石蜡的液相色谱-大气压化学电离质谱分析[J]. , 2012, 22(06): 67-70.